A Preliminary Experiment of Volatilization of Minerals in Coal Ash by Chlorination Treatment.
-
- SHIMADA Taihei
- Center for Advanced Research of Energy Technology, Hokkaido University
-
- KUMAGAI Takehiko
- Division of Material Science and Engineering, Graduate School of Engineering, Hokkaido University
-
- TSURUE Takashi
- Hokkaido National Industrial Research Institute
-
- NAKATA Yoshinori
- Hokkaido National Industrial Research Institute
-
- OKUTANI Takeshi
- Hokkaido National Industrial Research Institute
-
- TAKEDA Shohei
- Hokkaido National Industrial Research Institute
-
- HAYASHI Jun-ichiro
- Center for Advanced Research of Energy Technology, Hokkaido University
-
- CHIBA Tadatoshi
- Center for Advanced Research of Energy Technology, Hokkaido University
書誌事項
- タイトル別名
-
- Preliminary Experiment of Volatilizatio
この論文をさがす
抄録
Chlorination and volatilization characteristics of minerals in coal ashes were studied for chemical modification of the ash composition and properties. The ash samples were prepared by burning three bituminous coals, a lignite and a brown coal in a muffle furnace at 1088 K (high-temperature ash; HTA) and in an O2 plasma asher (low-temperature ash; LTA). On heating the ashes at 10 K/min to 1273 K in atmospheric chlorine gas flow in a thermobalance reactor, chlorination of minerals was found to take place even without oxygen sink and was followed by vaporization of the metal chlorides formed. Elemental analysis of the original and chlorine-treated HTAs revealed that most of K, Na, Mg and Fe and a portion of Ca were extracted while others such as Si and Al were hardly volatilized. Some pure metal oxides and a carbonate abundant in the ashes were treated at the same conditions. The result showed that Fe2O3 and Fe3O4 were rapidly volatilized in a temperature range of 900 to 1200 K. MgO was slowly but completely volatilized at 1273 K. Chlorination of CaO and CaCO3 occurred at much lower temperatures but vaporization of CaCl2 proceeded very slowly even at 1273 K. Changes in the ash weight with increasing temperature widely varied for the type of the initial ash. The variation was explained on the basis of the initial contents of metal oxides and carbonates. The chlorination treatment resulted in a significant reduction of differences in the mineral compositions, melting point temperatures and acid-base indices of residual solids from HTAs derived from the bituminous coals.
収録刊行物
-
- 日本エネルギー学会誌
-
日本エネルギー学会誌 76 (2), 134-144, 1997
一般社団法人 日本エネルギー学会
- Tweet
詳細情報 詳細情報について
-
- CRID
- 1390001204357992832
-
- NII論文ID
- 10002068246
-
- NII書誌ID
- AN10373883
-
- ISSN
- 18826121
- 09168753
-
- HANDLE
- 2115/74951
-
- NDL書誌ID
- 4150382
-
- 本文言語コード
- en
-
- データソース種別
-
- JaLC
- IRDB
- NDL
- Crossref
- CiNii Articles
-
- 抄録ライセンスフラグ
- 使用不可