Kinetics of Isothermal Reduction of MgO with Al

この論文にアクセスする

この論文をさがす

著者

    • YANG Jian
    • Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya University
    • KUWABARA Mamoru
    • Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya University
    • SAWADA Takashi
    • Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya University
    • SANO Masamichi
    • Department of Materials, Physics and Energy Engineering, Graduate School of Engineering, Nagoya University

抄録

Isothermal reduction of magnesium oxide with aluminum was carried out by use of an insertion tube charged with pellets composed of magnesium oxide and aluminum powders. Since the temperature in the tube increased rapidly during inserting the tube into a high temperature zone in the graphite crucible and decreased quickly during lifting up the tube to a low temperature zone, the isothermal reduction condition was essentially satisfied by the present method.<br>The reduction rate was increased with increasing temperature, carrier gas flow rate and pellet forming pressure. Even a little carrier gas could greatly increase the reduction rate of magnesium oxide.<br>The XRD patterns of pellets at different reduction stages confirmed that the aluminothermic reduction of magnesium oxide can be roughly classified into two stages. At the first stage, spinel, alumina and magnesium vapor were mainly produced; at the second stage, the spinel was further reduced by aluminum to produce alumina and magnesium vapor and the excessively added magnesium oxide was also reduced.<br>A kinetic model is established to describe the reduction rate of magnesium oxide. The apparent rate constant in the kinetic model increases with increasing temperature, carrier gas flow rate and pellet forming pressure. The apparent activation energy of the reduction is determined to be 109 kJ/mol.

収録刊行物

  • ISIJ international  

    ISIJ international 46(8), 1130-1136, 2006-08-15 

    The Iron and Steel Institute of Japan

参考文献:  27件

参考文献を見るにはログインが必要です。ユーザIDをお持ちでない方は新規登録してください。

各種コード

ページトップへ