Unsteady Pressure Coefficient around an Elliptic Immersion Nozzle

この論文にアクセスする

この論文をさがす

著者

    • UEDA Yoshiaki
    • Department of Energy Systems Engineering, Osaka Prefecture University
    • KIDA Teruhiko
    • Department of Energy Systems Engineering, Osaka Prefecture University
    • IGUCHI Manabu
    • Division of Materials Science and Engineering, Graduate School of Engineering, Hokkaido University

抄録

An unsteady molten steel meniscus flow sometimes occurs in the continuous casting mold. When it impinges on the immersion nozzle, a severe vertical pressure difference is induced on the outer surface of the nozzle. Mold powder entrapment near the immersion nozzle is closely associated with the pressure difference. The use of an elliptic immersion nozzle is expected to effectively lower the difference, and accordingly, suppress the mold powder entrapment. The pressure difference around the elliptic immersion nozzle however is not quantitatively known yet. In this study it was numerically calculated by the vortex method over a wide aspect ratio range of the nozzle for two types of unsteady meniscus flows. The validity of the numerical results was confirmed from a comparison with previous results obtained from cold model experiments.

収録刊行物

  • ISIJ international

    ISIJ international 44(8), 1403-1409, 2004-08-15

    The Iron and Steel Institute of Japan

参考文献:  14件中 1-14件 を表示

  • <no title>

    TANIGUCHI S.

    Tetsu-to-Hagane 78, 527, 1992

    被引用文献17件

  • <no title>

    Jpn. Soc. Prom. Sci. 19th Committee

    Recent Development in Studies of Non-metallic Inclusions in Steel, 1994

    被引用文献1件

  • <no title>

    IGUCHI M.

    Fluid Flow in Continuous Casting Mold and Behavior of Non-metallic Inclusions, 2003

    被引用文献1件

  • <no title>

    YOSHIDA J.

    Tetsu-to-Hagane 87(8), 529, 2001

    被引用文献1件

  • <no title>

    YOSHIDA J.

    Tetsu-to-Hagane 88(5), 264, 2002

    被引用文献1件

  • <no title>

    CHOU M-H.

    Int. J. Numerical Methods in Fluids 23, 711, 1996

    被引用文献1件

  • <no title>

    HOERNER S. F.

    Fluid Dynamic Drag, 1965

    被引用文献7件

  • <no title>

    BLEBINS R. D.

    Applied Fluid Dynamics, 1984

    被引用文献1件

  • <no title>

    KAMEMOTO K.

    J. Jpn. Soc. Comp. Fluid Dynamics 2(1), 20, 1993

    被引用文献1件

  • <no title>

    KAMEMOTO K.

    J. Jpn. Soc. Comp. Fluid Dynamics 2(2), 28, 1994

    被引用文献1件

  • <no title>

    KIDA T.

    Computational Fluid Dynamics J. 9(2), 64, 2000

    被引用文献1件

  • <no title>

    UEDA Y.

    Computational Fluid Dynamics J. 11(2), 213, 2002

    被引用文献1件

  • <no title>

    SCHLICHTING H.

    Boundary-Layer Theory 425, 1979

    被引用文献1件

  • <no title>

    YOSHIDA J.

    Tetsu-to-Hagane 87(12), 741, 2001

    被引用文献1件

各種コード

ページトップへ