Joint Properties of Cast Fe-Pt Magnetic Alloy Laser-welded to Co-Cr Alloy
-
- BABA Naoki
- Department of Developmental and Reconstructive Medicine, Division of Fixed Prosthodontics and Oral Rehabilitation, Nagasaki University Graduate School of Biomedical Sciences
-
- WATANABE Ikuya
- Department of Biomaterials Science, Baylor College of Dentistry, Texas A&M University System Health Science Center
-
- TANAKA Yasuhiro
- Department of Developmental and Reconstructive Medicine, Division of Dental and Biomedical Materials Science, Nagasaki University Graduate School of Biomedical Sciences
-
- HISATSUNE Kunihiro
- Department of Developmental and Reconstructive Medicine, Division of Dental and Biomedical Materials Science, Nagasaki University Graduate School of Biomedical Sciences
-
- ATSUTA Mitsuru
- Department of Developmental and Reconstructive Medicine, Division of Fixed Prosthodontics and Oral Rehabilitation, Nagasaki University Graduate School of Biomedical Sciences
Access this Article
Search this Article
Author(s)
-
- BABA Naoki
- Department of Developmental and Reconstructive Medicine, Division of Fixed Prosthodontics and Oral Rehabilitation, Nagasaki University Graduate School of Biomedical Sciences
-
- WATANABE Ikuya
- Department of Biomaterials Science, Baylor College of Dentistry, Texas A&M University System Health Science Center
-
- TANAKA Yasuhiro
- Department of Developmental and Reconstructive Medicine, Division of Dental and Biomedical Materials Science, Nagasaki University Graduate School of Biomedical Sciences
-
- HISATSUNE Kunihiro
- Department of Developmental and Reconstructive Medicine, Division of Dental and Biomedical Materials Science, Nagasaki University Graduate School of Biomedical Sciences
-
- ATSUTA Mitsuru
- Department of Developmental and Reconstructive Medicine, Division of Fixed Prosthodontics and Oral Rehabilitation, Nagasaki University Graduate School of Biomedical Sciences
Abstract
This study investigated the joint properties of Fe-Pt alloy laser-welded to Co-Cr alloy. Cast plates (0.5×3.0×10mm) were prepared with Fe-Pt and Co-Cr alloys. Fe-Pt plates were butted against Co-Cr plates and laser-welded using Nd: YAG laser. Control and homogeneously welded specimens were also prepared. Laser welding was performed with and without argon shielding. Tensile testing was conducted, and both fracture force (Ff: N) and elongation (El: %) were recorded. There were no differences in the Ff value between the specimens with and without argon shielding for the welded Fe-Pt/Co-Cr. Lower Ff value of the welded specimen was obtained in the order of Fe-Pt alloy<Fe-Pt/Co-Cr<Co-Cr alloy. The results indicated that Fe-Pt welded to Co-Cr had Ff values between the values of homogeneously welded Fe-Pt and Co-Cr alloys. Argon shielding, on the other hand, had no effect on the weld strength between Fe-Pt and Co-Cr alloys.
Journal
-
- Dental Materials Journal
-
Dental Materials Journal 24(4), 550-554, 2005-12-01
The Japanese Society for Dental Materials and Devices
References: 28
-
1
- On the high energy product of Fe-Pt permanent magnet alloys
-
WATANABE K
J Japan Inst Metals 47, 699-703, 1983
Cited by (1)
-
2
- The effect of various additional elements on properties of Fe-Pt permanent magnets having high energy product
-
WATANABE K
Mater Trans JIM 26, 362-368, 1985
Cited by (1)
-
3
- Permanent magnet properties in Fe-Pt-Nb system alloys
-
WATANABE K.
J Japan Inst Metals 54, 1284-1290, 1990
Cited by (1)
-
4
- Attractive force of castable iron-platinum magnetic alloys
-
WATANABE I
Dent Mater 17, 197-200, 2001
Cited by (1)
-
5
- In vitro corrosion behavior of cast iron-platinum magnetic alloys
-
WATANABE I
Dent Mater 17, 217-220, 2001
Cited by (1)
-
6
- Application of cast iron platinum keeper to a collapsible denture for a patient with constricted oral opening : A clinical report
-
OHKUBO C
J Prosthet Dent 90, 6-9, 2003
Cited by (1)
-
7
- The effect of low level laser irradiation on implant-tissue interaction : In vivo and in vitro studies
-
KHADRA M.
Swed Dent J Suppl 172, 1-63, 2005
Cited by (1)
-
8
- Comparison of laser-welded titanium and conventional cast frameworks supported by implants in the partially edentulous jaw : A 3-year prospective multicenter study
-
JEMT T
Int J Prosthodont 13, 282-288, 2000
Cited by (1)
-
9
- Installing magnetic keepers using laser welding
-
ISHIKAWA M
J Prosthet Dent 11, 49-52, 2002
Cited by (1)
-
10
- Argon-shielding effect on Nd : YAG laser penetration into Ti and Co-Cr
-
CHIU YF
J Dent Res 84(Special issue), 1602, 2005
Cited by (1)
-
11
- <no title>
-
CRAIG GR
Restorative dental materials, 2002
Cited by (1)
-
12
- <no title>
-
ANUSAVICE JK.
Phillips' science of dental materials, 2003
Cited by (1)
-
13
- <no title>
-
MASSALSKI TB.
Binary alloy phase diagrams, 1990
Cited by (1)
-
14
- Permanent magnet properties and their temperature dependence in the Fe-Pt-Nb alloy system
-
WATANABE K.
Mater Trans JIM 32, 292-298, 1991
Cited by (1)
-
15
- <no title>
-
TANAKA Y.
J. Magn. Magn. Mater. 170, 289, 1997
Cited by (5)
-
16
- Application of cast magnetic attachments to sectional complete dentures for a patient with microstomia : a clinical report
-
WATANABE I
J Prosthet Dent 88, 573-577, 2002
DOI Cited by (4)
-
17
- Effects of low power Er : YAG laser on the tooth pulp-evoked jaw-opening reflex
-
ZEREDO J. L.
Lasers Surg Med 33, 169-172, 2003
DOI Cited by (2)
-
18
- Laser welding of prostheses-an initial report
-
GORDON TE
J Prosthet Dent 24, 472-476, 1970
DOI Cited by (16)
-
19
- Laser welding of thin sheet steel with surface oxidation
-
XIE J
Welding J 78, 343-348, 1999
Cited by (2)
-
20
- Tensile properties and hardness of cast Fe-Pt magnetic alloys
-
WATANABE I.
J Prosthet Dent 92, 278-282, 2004
DOI Cited by (4)
-
21
- Properties of cobalt-chromium metal ceramic alloys after heat treatment
-
MORRIS HF.
J Prosthet Dent 63, 426-433, 1990
DOI Cited by (1)
-
22
- Output Energy Changes of Quartz Contact Probe for Er:YAG Laser with Tooth Ablation
-
YAMAZAKI Koichiro , EGURO Toru , MAEDA Toru , TANAKA Hisayoshi
Dental Materials Journal 22(3), 292-300, 2003-09-01
J-STAGE NDL Digital Collections Ichushi Web References (20) Cited by (4)
-
23
- Nd : YAG Laser Ablation of Enamel for Orthodontic Use : Tensile Bond Strength and Surface Modification
-
KWON Yong Hoon , KWON Oh-Won , KIM Hyung-II , KIM Kyo-Han
Dental Materials Journal 22(3), 397-403, 2003-09-01
J-STAGE NDL Digital Collections Ichushi Web References (22) Cited by (3)
-
24
- Nd : YAG Laser Ablation and Acid Resistance of Enamel
-
KWON Yong Hoon , KWON Oh-Won , KIM Hyung-Il , KIM Kyo-Han
Dental Materials Journal 22(3), 404-411, 2003-09-01
J-STAGE NDL Digital Collections Ichushi Web References (19) Cited by (3)
-
25
- Imaging and Non-Contact Profile Analysis of Nd : YAG Laser-Irradiated Teeth by Scanning Electron Microscopy and Confocal Laser Scanning Microscopy
-
YAMADA Kiyoko , WATARI Fumio
Dental Materials Journal 22(4), 556-568, 2003-12-01
J-STAGE NDL Digital Collections Ichushi Web References (23) Cited by (3)
-
26
- Metallurgical Effects on Titanium by Laser Welding on Dental Stone
-
FUJIOKA Sonosuke , KAKIMOTO Kazutoshi , INOUE Taro , OKAZAKI Joji , KOMASA Yutaka
Dental Materials Journal 22(4), 581-591, 2003-12-01
J-STAGE NDL Digital Collections Ichushi Web References (19) Cited by (7)
-
27
- Distortion of Laser Welded Titanium Plates
-
IWASAKI Keiji , OHKAWA Shoji , ROSCA Iosif D. , UO Motohiro , AKASAKA Tsukasa , WATARI Fumio
Dental Materials Journal 23(4), 593-599, 2004-12-01
J-STAGE NDL Digital Collections Ichushi Web References (22) Cited by (8)
-
28
- Basic Study on Laser Welding of Dental Materials:The Use of Laser Welding in Prosthodontics The first report
-
Minamizato Takehito
Nihon Hotetsu Shika Gakkai Zasshi 17(4), 524-529, 1973
J-STAGE Ichushi Web Cited by (5)
Cited by: 1
-
1
- Femtosecond Pulse Laser-oriented Recording on Dental Prostheses : A Trial Introduction
-
ICHIKAWA Tetsuo , HAYASAKI Yoshio , FUJITA Keiji , NAGAO Kan , MURATA Masayo , KAWANO Takanori , CHEN JianRong
Dental Materials Journal 25(4), 733-736, 2006-12-01
J-STAGE NDL Digital Collections Ichushi Web References (15) Cited by (1)